INTRODUCTION

1. OUR MISSION IS TO SUPPLY OUR INTERNATIONAL CUSTOMER'S THE MOST ADVANCED GREEN TECHNOLOGY WITH THE HIGHEST SUPERIOR PERFORMANCE, ULTIMATE POWER AND STORAGE SOLUTIONS FOR ALL YOUR APPLICATIONS.  AFTER SEVEN YEARS OF TESTING BY THE MILITARY WE WERE APPROVED AND LICENSED TO SUPPLY THE BOLT ULTRA BATTERY FOR FIGHTER JETS, SUBMARINES, TELECOMMUNICATION, UPS, WIND AND SOLAR SYSTEMS.

• WORLD PATENT PROTECTED ELECTROLYTE IS COMPOSED OF SILICATE SALT COMPOUNDS.
• ADVANCED GREEN TECHNOLOGY THAT HAS NO ACID MIST OR POLLUTION FROM THE ELECTROLYTE.
• WHEN THE BATTERY COMES TO THE END OF IT'S LIFE CYCLE, THE BOLT ULTRA BATTERY CAN BE REFURBISHED AT A NEARBY LOCATION TO SAVE APPROXIMATE 40% ON BATTERY REPLACEMENT AND SAVE ON TRANSPORTATION COSTS.
• TEMPERATURE ENDURANCE WITH SUPERIOR HIGH PERFORMANCE IN HARSH TEMPERATURES OF -40⁰C TO +70⁰C, WORKS NORMAL IN EXTREME TEMPERATURES.
• THE BOLT SILICATE BATTERY PERFORMS EXTREMELY WELL IN OUTDOOR ENVIRONMENTS, VRLA AND OTHER LEAD ACID BATTERIES LOSES APPROXIMATELY 40% OF IT’S CHARGING CYCLES FOR EVERY 8⁰C INCREASE IN TEMPERATURES EXCEEDING 25⁰C, THE BOLT ULTRA BATTERY CHANGE IS INSIGNIFICANT IN TEMPERATURES UNDER +70⁰C.
• NO ACID MIST, NO CORROSION TO CORRODE PLATES, ELECTRODES, JOINTS AND CONNECTIONS PROLONGING THE BATTERY LIFE.
• THE BOLT ULTRA BATTERY HAS UP TO 2200+ CHARGING CYCLES
• WHEN USING 50% DEPTH OF DISCHARGE, APPROXIMATELY FOUR TIMES MORE CHARGING CYCLES THAN THAT OF LEAD-ACID BATTERIES,
• THE BOLT ULTRA HAS THE CAPABILITY TO BE DISCHARGE TO 100% WITH NO DAMAGE TO THE BATTERY BUT IS RECOMMENDED TO RECHARGE THE BATTERY IMMEDIATELY AFTER HIGH DISCHARGE TO PROLONG BATTERY LIFE AND CHARGING CYCLES, IT IS RECOMMENDED NOT TO EXCEED 90% DISCHARGE TO RETAIN CHARGING CYCLES.
• SELF DISCHARGE RATE IS APPROXIMATELY 10% PER YEAR WHEN STORED AT AMBIENT TEMPERATURES OF 20⁰C / 25⁰C.
• THE BATTERY HAS UP TO 50% HIGHER SPECIFIC ENERGY DENSITY THAN THAT OF THE VRLA BATTERY
• THE BOLT ULTRA BATTERY HAS A LOWER INTERNAL RESISTANCE OF 2mΩ / 5mΩ (Milli-ohm) WITH LITTLE TEMPERATURE RISE, THE 12V LEAD-ACID BATTERY HAS UP TO 25mΩ (Milli-ohm).
• THE BOLT ULTRA BATTERY EXCEEDS INTERNATIONAL STORAGE CAPACITY STANDARDS BY 1.75 TIMES AND EXCEEDS INTERNATIONAL RECHARGE ACCEPTANCE CAPACITY STANDARDS BY 2.68 TIMES.
• BECAUSE THE BOLT ULTRA BATTERY DOES NOT EMIT ACID MIST EMISSIONS THERE IS NO NEED FOR SEPARATE ENCLOSURES, NO VENTILATION SYSTEMS, NO COOLING SYSTEMS, NO ACID MATTING REQUIRED, SAVING ON INSTALLATIONS, MAINTENANCE AND ENERGY COSTS.
• THE BOLT ULTRA BATTERY LIFE DESIGN IS 15+ YEARS.
• UP TO 7000+ CYCLES FOR TELECOMMUNICATION STANDBY APPLICATIONS.

BATTERY CHARGING

• DUE TO THE SPECIAL CAPABILITIES OF THE BOLT ULTRA BATTERY, CONSTANT CURRENT CHARGING IS RECOMMENDED TO PROLONG THE LIFE OF THE BATTERY, HOWEVER, SINCE THE CHARGING ABILITY OF THE BOLT ULTRA BATTERY IS QUITE STRONG IT CAN ADAPT TO BOTH CONSTANT VOLTAGE OR CONSTANT CURRENT CHARGING WITH MINIMAL EFFECT.
• THE TOP RECOMMENDED CHARGE VOLTAGE IS 2.45 V/CELL, THE BOLT ULTRA BATTERY WILL NOT GET TOP LOADED LIKE LEAD ACID BATTERIES AND WILL NOT UNDERGO GAS EMISSION PROBLEMS OR BATTERY DAMAGE.
• THE BATTERY HAS THE CAPABILITY TO BE FAST CHARGED IN 60 MINUTES AT 3C / 14.4V
• WHEN CHARGING WITH AN ORDINARY LEAD ACID BATTERY CHARGER WITH LOWER CHARGING VOLTAGE THE BATTERY MAY NOT GET FULLY CHARGED TO FULL CAPACITY.
• WHEN FLOAT CHARGING, THE HIGHEST RECOMMENDED ACCEPTABLE CURRENT IS 0.6C. THE RECOMMENDED FLOAT CHARGE VOLTAGE PER CELL IS 2.27V AT 20⁰C WHEN USING CONSTANT CURRENT CHARGING, THE RECOMMENDED VOLTAGE PER CELL IS 2.35V THAT WILL FULLY CHARGE THE BATTERY.

BATTERY DISCHARGING

• DUE TO THE SPECIAL CAPABILITIES OF THE BOLT ULTRA BATTERY CONSTANT CURRENT DISCHARGING IS RECOMMENDED TO PROLONG THE LIFE OF THE BATTERY. HOWEVER, SINCE THE DISCHARGING ABILITY OF THE BOLT ULTRA IS STRONG, IT CAN ADAPT TO BOTH CONSTANT VOLTAGE OR CONSTANT CURRENT WITH MINIMAL EFFECT.
• UNDER NORMAL CIRCUMSTANCES CHARGING AND DISCHARGING RATIO OF 1:0.3 IS RECOMMENDED. HOWEVER, WITH HIGH CURRENT CHARGING AND DISCHARGING THE RATIO CAN BE SHIFTED TO 1:1
• THE MANUFACTURER ADVISES THE END USER TO CHARGE THE BATTERY IMMEDIATELY AFTER HIGH DISCHARGE TO PROLONG THE LIFE OF THE BATTERY AND CHARGING CYCLES. TO PROLONG THE BATTERY LIFE AND SAVE CHARGING CYCLES THE MANUFACTURER SUGGESTS NOT TO EXCEED 90% DISCHARGE